2870 OFFSHORE2870 OFFSHOREOWNER’S MANUALFISHING BOATS3901 St. Lucie Blvd.Ft. Pierce, Florida 34946Print Date 3/00
2870 OFFSHORES2 Yachts will confirm, in writing, that the transfer of the warranty has taken place. After which,the transferee will be treated as th
2870 OFFSHOREFine scratches can be removed with a fine automotive clear coat polishing compound. A coat ofautomotive or boat wax is beneficial to pr
2870 OFFSHORE• Dry soil, dust and dirt - Remove with a soft cloth.• Dried on dirt - Wash with a soft cloth dampened with water.• Variations in surfac
2870 OFFSHOREDo not operate engines, fuel consuming heaters or burners with the canvas enclosures closed. Thecockpit must be open for legal ventilat
2870 OFFSHOREALWAYS READ THE LABEL CAREFULLY ON MILDEW PROTECTORS. REMOVE THEPROTECTOR AND ALLOW THE CABIN TO VENTILATE COMPLETELY BEFORE USINGTHE C
2870 OFFSHORETHIS PAGE WAS LEFT BLANKINTENTIONALLY
2870 OFFSHOREChapter 14:SEASONAL MAINTENANCE14.1 Lay-up and StorageBefore Hauling:• Pump out the head. Flush the holding tank using clean soap, wat
2870 OFFSHORE14-2LiftingIt is essential that care be used when lifting your boat. Make sure the spreader bar at each sling isat least as long as the
2870 OFFSHORESupporting The Boat For StorageYour trailer or a well-made cradle is the best support for your boat during storage.When storing the boat
2870 OFFSHORE• Remove propellers and grease the propeller shafts using light waterproof grease.• Remove the batteries and store in a cool place. Cle
2870 OFFSHOREThe cabin drain sump system must be properly winterized. Clean debris from the drain and sumpand flush for several minutes with fresh c
2870 OFFSHORERegistration and NumberingFederal law requires that all undocumented vessels equipped with propulsion machinery beregistered in the stat
2870 OFFSHORE14-6Hard TopIt is imperative that all drain holes in the legs are open and that the legs are completely free of water.Remove the canvas
2870 OFFSHORENote: It is important and recommended that the fitting out procedure for the marine gearbe done by a qualified service person. Read the
2870 OFFSHORE• Carefully monitor the gauges and check for leakage and abnormal noises.• Operate the boat at slow speeds until the engine temperature
2870 OFFSHORE15-1Chapter 15:SCHEMATICS12-Volt DC Wiring Schematic
2870 OFFSHORE15-2110-Volt Wiring Schematic
2870 OFFSHORE15-3Hydraulic Steering SystemHydraulic LinesTie BarSteering CylinderHelm
2870 OFFSHORE15-4Fuel System
2870 OFFSHORE15-5Fuel Selector Valves
2870 OFFSHORE15-6Freshwater System
2870 OFFSHORE15-7Raw Water SystemLivewellPumpStrainerRaw WaterPumpWashdownConnectorThru-HullIntakeLivewellHeadHead IntakeThru-HullStrainerStrainerLiv
2870 OFFSHOREregulations. They can also help in providing local navigational information when moving to a newboating area. Contact your dealer, St
2870 OFFSHORE15-8Head SystemHead System with Macerator
2870 OFFSHORE15-9Hull Drainage System
2870 OFFSHORE15-10Cockpit Drainage SystemFishboxDrainSink DrainRigged BaitStorageDrainScupper DrainCockpitDrainCockpitDrainScupper DrainEngine WellDr
2870 OFFSHORE15-11Sling Positions
2870 OFFSHORETHIS PAGE WAS LEFT BLANKINTENTIONALLY
2870 OFFSHOREAPPENDIX A:GLOSSARY OF TERMSAft: In, near, or toward the stern of a boat.Aground: A boat stuck on the bottom.Amidship: In or toward t
2870 OFFSHOREBoat Hook: Short shaft of wood or metal with a hook fitting at one end shaped to aid in extendingone’s reach from the side of the boat.
2870 OFFSHOREDeck: The floor-like platform of a boat that covers the hull.Displacement: The volume of water displaced by the hull. The displacemen
2870 OFFSHOREGround Tackle: A general term including anchors, lines, and other gear used in anchoring.Grounds: A boat touches the bottom.Gunwale:
2870 OFFSHORELength On The Waterline (l.w.l.): A length measurement of a boat at the waterline from the sternto where the hull breaks the water near
2870 OFFSHORETABLE OF CONTENTSChapter 1: Propulsion SystemPage1.1 General ...
2870 OFFSHOREPitching: The fore and aft rocking motion of a boat as the bow rises and falls.Pitch: The measure of the angle of a propeller blade.
2870 OFFSHORESeacock: Safety valves installed just inside the thru-hull fittings and ahead of the piping or hoserunning from the fittings.Shaft Log:
2870 OFFSHORETaffrail: Rail around the rear of the cockpit.Thru-hull: A fitting used to pass fluids (usually water) through the hull surface, eithe
2870 OFFSHOREAppendix B:HoursDate DealerService/RepairsMAINTENANCE LOGB-1
2870 OFFSHOREHoursDate DealerService/RepairsMAINTENANCE LOGB-2
2870 OFFSHOREHoursDate DealerService/RepairsMAINTENANCE LOGB-3
2870 OFFSHOREHoursDate DealerService/RepairsMAINTENANCE LOGB-4
2870 OFFSHOREHoursDate DealerService/RepairsMAINTENANCE LOGB-5
2870 OFFSHOREHoursDate DealerService/RepairsMAINTENANCE LOGB-6
2870 OFFSHOREC-1Appendix C:BOATING ACCIDENT REPORTFORM APPROVEDOMB NO.211-0010DEPARTMENT OFTRANSPORTATIONU.S. COAST GUARDC.G. 1865 (REV. 1/88)The ope
2870 OFFSHORETABLE OF CONTENTSChapter 5: Freshwater SystemPage5.1 General ...
2870 OFFSHOREC-2If more than 3 fatalities and/or injuries, attach additional form(s)WAS VICTIM?[ ] Swimmer[ ] Non SwimmerDATE OFBIRTHADDRESSNAME DE
2870 OFFSHORETABLE OF CONTENTSChapter 8: Ventilation SystemPage8.1 Cabin Ventilation ...
2870 OFFSHORETABLE OF CONTENTSChapter 11: Exterior EquipmentPage11.1 Deck ...
2870 OFFSHORETABLE OF CONTENTSChapter 15: Schematics Page12-Volt DC Wiring Schematic ...15-1110-
2870 OFFSHORETHIS PAGE WAS LEFT BLANKINTENTIONALLY
2870 OFFSHOREChapter 1:PROPULSION SYSTEM1.1 GeneralThe Pursuit 2870 Offshore is designed to be powered with twin 2 cycle outboard motors. Mostoutboa
2870 OFFSHORETHIS PAGE WAS LEFT BLANKINTENTIONALLY
2870 OFFSHOREDO NOT INHALE EXHAUST FUMES! EXHAUST CONTAINS CARBON MONOXIDE THAT ISCOLORLESS AND ODORLESS. CARBON MONOXIDE IS A DANGEROUS GAS THAT I
2870 OFFSHORE1.4 Engine Cooling SystemOutboard engines are raw water (sea water) cooled. Water is pumped through the water inlets,circulated through
2870 OFFSHORE1.6 Engine InstrumentationThe helm station is equipped with a set ofengine instruments and/or alarms. These instru-ments allow the pilo
2870 OFFSHORE1-5DO NOT OPERATE THE ENGINE(S) IF LOW WATER PRESSURE IS INDICATED. THISCOULD BE AN INDICATION OF A COOLING SYSTEM BLOCKAGE OR AN IMPEL
2870 OFFSHORE1-6Depth GaugeThe depth gauge indicates the depth of the water below the bottom of the boat.CompassThe compass is on top of the helm. T
2870 OFFSHOREChapter 2:HELM CONTROL SYSTEMS2.1 GeneralThe helm controls consist of three systems: the engine throttle and shift controls, the steer
2870 OFFSHORE2.3 Neutral Safety SwitchEvery control system has a neutral safety switch incorporated into it. This device prohibits theengine from be
2870 OFFSHORETHE ENGINE HOSES AND CABLES OR THE TRANSOM GEL COAT CAN BE DAMAGEDBY TILTING THE ENGINES TO THE FULL UP POSITION WITH THE ENGINES TURNED
2870 OFFSHORE2.6 Steering SystemThe steering system is hydraulic and made of two main components: the helm assembly and thehydraulic cylinder. The
2870 OFFSHOREAlways establish the intended heading and cruise speedbefore attempting to adjust the hull attitude with the trimtabs. After stabilizin
2870 OFFSHORE iSAFETY INSTRUCTIONSYour 2870 Offshore Owner’s Manual hasbeen written to include a number of safety instructions toassure the safe ope
2870 OFFSHOREDO NOT ATTEMPT CONTROL ADJUSTMENTS UNLESS YOU ARE FAMILIAR WITH SER-VICING CONTROL SYSTEM PROCEDURES. CONTROL MISADJUSTMENT CAN CAUSELO
2870 OFFSHORE3-1Chapter 3:FUEL SYSTEM3.1 GeneralThe gasoline fuel system used in Pursuit boats is designed to meet or exceed the requirements ofthe
2870 OFFSHOREFuel Withdrawal TubesThe fuel withdrawal tubes are positioned in the fuel tanks to achieve optimum fuel usage, fuel linerouting, etc. A
2870 OFFSHOREAfter fueling, replace the fill cap(s), and wash the areas around the fuel fill plates and below the fuelvent(s). Residual fuel left on
2870 OFFSHORE3-4DO NOT REMOVE THE ANTI-SIPHON VALVES FROM THE SYSTEM. SHOULD THEVALVES BECOME CLOGGED, CLEAN AND REINSTALL OR REPLACE.Fuel filters a
2870 OFFSHORE5. A special key to open the fuel caps is supplied.6. Turn the key counterclockwise to open the cap.7. Remove the cap.8. Put the nozzle
2870 OFFSHORE3.4 Fuel System MaintenancePeriodically inspect all primer bulbs, connections, clamps and hoses for leakage and damage ordeterioration.
2870 OFFSHOREDO NOT DRAIN ANY FUEL INTO THE BILGE. THIS COULD LEAD TO A FIRE OR EX-PLOSION.AFTER THE FILTER ELEMENTS HAVE BEEN CHANGED, PRIME THE FU
2870 OFFSHORETHIS PAGE WAS LEFT BLANKINTENTIONALLY
2870 OFFSHOREChapter 4:ELECTRICAL SYSTEM4.1 GeneralYour Pursuit is equipped with a 12-volt DC electrical system and a 110-volt AC system. The ACsy
2870 OFFSHORETHIS PAGE WAS LEFT BLANKINTENTIONALLY
2870 OFFSHOREThere are two (2) battery selector switches located in thetransom area of the boat. One battery switch feeds the starboardengine and th
2870 OFFSHORE12-Volt Accessory Switch PanelsThe main accessory switch panel is located at the helm. The circuit breakers that protect theaccessori
2870 OFFSHOREAccessory Switches (3)These switches are supplied to protect additional equipment that may or may not have been installedby Pursuit or y
2870 OFFSHORE4-5Windlass SwitchLocated in the helm. This switch controls the optional windlass which is mounted to the deckdirectly above the rope l
2870 OFFSHORE4-6Electric HeadSupplies electrical current directly to the switch which controls the optional electric head. Alsosupplies electrical c
2870 OFFSHORETO REDUCE THE POSSIBILITY OF AN ELECTRICAL SHOCK, IT IS IMPORTANT THATTHE 110-VOLT AC GROUND SYSTEM IS FUNCTIONING PROPERLY AND THAT A P
2870 OFFSHORE4-8UNDETECTED FAULTS IN THE AC ELECTRICAL SYSTEM COULD CAUSE THE WATERAROUND THE BOAT TO BECOME ENERGIZED. THIS COULD CAUSE A SEVERE SH
2870 OFFSHOREGFI OUTLETS DO NOT PROVIDE 100% PROTECTION FROM ELECTRIC SHOCK. EVENTHOUGH GROUND FAULT INTERRUPTERS PROVIDE PROTECTION BY REDUCING EXP
2870 OFFSHORECheck the electrolyte level in the batteries regularly and add distilled water as necessary. If thebatteries are frequently charged by
2870 OFFSHORE5-1Freshwater SystemChapter 5:FRESHWATER SYSTEM5.1 GeneralThe freshwater system consists of a potable water tank, distribution lines an
2870 OFFSHOREDear Pursuit 2870 Offshore Owner:All of us at Pursuit are pleased that you have selected one of our products asyour boat. As I’m sure
2870 OFFSHORE5-25.2 Freshwater System OperationFill the water supply tank slowly through the labeled deck plate. After fillingthe water tank, partia
2870 OFFSHORE5-3DO NOT MODIFY OR CHANGE THE SHORE WATER INLET CONNECTOR WITH ANOTHERTYPE WITHOUT CONSULTING PURSUIT CUSTOMER RELATIONS OR YOUR DEALER
2870 OFFSHORE5-4THE FRESHWATER SYSTEM MUST BE PROPERLY WINTERIZED PRIOR TO WINTER LAY-UP. SEE SECTION ON WINTERIZING.THE WATER PRESSURE BREAKER SHOU
2870 OFFSHOREChapter 6:RAW WATER SYSTEM6.1 GeneralIn the raw or sea water systems, all water pumps are supplied by hoses connected to ball valves an
2870 OFFSHORE6.2 High Pressure WashdownA saltwater high pressure pump, controlled by a pressure sensor,supplies the raw water hose connector located
2870 OFFSHORE6.3 LivewellSea water is provided to the livewell by a 12-volt diaphragm pump. This pump is designed to carrya constant flow of water t
2870 OFFSHORE6-46.4 Raw Water System MaintenanceThe following items should be done routinely to help maintain your raw water system:• Check hoses, pa
2870 OFFSHORE7-1Chapter 7:DRAINAGE SYSTEMS7.1 GeneralAll water is drained by gravity to overboard thru hull fittings located in the hull sides abov
2870 OFFSHORE7-27.3 Hard-Top DrainsThere is a hole drilled in one of the leg bases to prevent water from being trapped within the legand provide a w
2870 OFFSHORETHE FEDERAL WATER POLLUTION CONTROL ACT PROHIBITS THE DISCHARGE OF OILOR OILY WASTE INTO OR UPON THE NAVIGABLE WATERS OF THE UNITED STA
2870 OFFSHORETHIS PAGE WAS LEFT BLANKINTENTIONALLY
2870 OFFSHOREsea water from entering the boat through the sump system. The drain valve is located on the portside of the storage compartment below
2870 OFFSHOREChapter 8:VENTILATION SYSTEM8.1 Cabin VentilationVentilation to the cabin area is provided by a deck hatch andopening port windows.Port
2870 OFFSHORE“station wagon effect” where engine exhaust fumes are captured in the vacuum or low pressurearea, usually the cockpit, bridge deck and c
2870 OFFSHORE8.3 Maintenance• Periodically lubricate all hinges, adjusters and latch assemblies with a light oil.• Periodically clean and coat gasket
2870 OFFSHORETHIS PAGE WAS LEFT BLANKINTENTIONALLY
2870 OFFSHOREChapter 9:SAFETY EQUIPMENT9.1 GeneralYour boat and outboard engines have been equipped with safety equipment designed to enhancethe saf
2870 OFFSHORE• If the boat is equipped with water sensors in the fuel filters, be sure to check them for excessivewater.9.3 Neutral Safety SwitchEver
2870 OFFSHOREVirginia, for information on boat safety courses and brochures listing the Federal equipmentrequirements. Also, check your local and st
2870 OFFSHORENon-Pyrotechnic Devices:Non-Pyrotechnic visual distress signals must be in serviceable condition, readily accessible, andcertified by th
2870 OFFSHOREPlease refer to the information provided by the fire extinguisher manufacturer for instructions onthe proper maintenance and use of your
2870 OFFSHOREiiiBOAT INFORMATIONMAKE:SERIAL #:MODEL:GVRW:PHONE:REPRESENTATIVE:TRAILERNAME:DEALER/PHONE:ADDRESS:SERVICE MANAGER:ADDRESS:SALESMAN:DEAL
2870 OFFSHOREAlways make sure the Cabin DC Breaker Panel and the carbon monoxide detector are activatedby the battery selector switch whenever the ca
2870 OFFSHORERemember, carbon monoxide detectors do not guarantee that CO poisoning will not occur. Do notuse the CO detector as a replacement for o
2870 OFFSHOREIn many emergency situations, the Coast Guard can provide assistance in obtaining medical advicefor treatment of serious injuries or ill
2870 OFFSHOREChapter 10:OPERATION10.1 GeneralBefore you start the engines on your Pursuit, you should have become familiar with the variouscomponen
2870 OFFSHORESAILBOATS NOT UNDER POWER, PADDLE BOATS, VESSELS UNABLE TO MANEUVER,VESSELS ENGAGED IN COMMERCIAL FISHING AND OTHER VESSELS WITHOUT POWE
2870 OFFSHORE10.3 Pre-Cruise CheckBefore Starting the Engines• Check the weather forecast. Decide if the planned cruise can be made safely.• Be sure
2870 OFFSHORE• Have a tool kit aboard. The kit should include the following basic tools:Spark plug wrench HammerSpark plug gap gauge Electrician’s T
2870 OFFSHORE• Check the controls and steering for smooth and proper operation.• Make sure all lines, cables, anchors, etc. for securing a boat are o
2870 OFFSHORE10-6Note: For more instructions on safety, equipment and boat handling, enroll in one of theseveral free boating courses offered. For i
2870 OFFSHORE10-710.5 Tower Operation (Dealer Option)Your boat could be equipped with a fabricated aluminum tower by your dealer. Towers arenormall
2870 OFFSHORETHIS PAGE WAS LEFT BLANKINTENTIONALLY
2870 OFFSHORE• Always put the boat in NEUTRAL before moving to and from the tower helm and cockpit.GOOD COMMON SENSE, JUDGMENT AND EXTREME CAUTION MU
2870 OFFSHORETHE MOORING CLEATS ON PURSUIT BOATS ARE NOT DESIGNED OR INTENDED TO BEUSED FOR TOWING PURPOSES. THESE CLEATS ARE SPECIFICALLY DESIGNED
2870 OFFSHOREThe following safety tips and a book titled “Sportfish, Cruisers, Yachts - Owner's Manual,”included in your literature packet, pro
2870 OFFSHORE• The COUPLER MUST BE COMPLETELY OVER THE BALL and the LATCHINGMECHANISM LOCKED DOWN.• Make sure the TRAILER IS LOADED EVENLY from fro
2870 OFFSHORETHIS PAGE WAS LEFT BLANKINTENTIONALLY
2870 OFFSHOREChapter 11:EXTERIOR EQUIPMENT11.1 DeckRails and Deck HardwareThe rail system and hardware fittings have been selected and installed to
2870 OFFSHOREThe anchor locker is drained by thru hull fittings in the hull sides near the bottom of the locker. Itis very important to check the dr
2870 OFFSHORE11-311.2 HullSwim PlatformYour Pursuit is equipped with an integral swim platform and engine mounting system located inthe stern of the
2870 OFFSHORELeaning Post/BaitwellThe leaning post/baitwell is equipped with rod holders, a leaning post cushion, storage, and acirculating livewell.
2870 OFFSHOREALWAYS MAKE SURE THE HELM STATION CLAMPS ARE PROPERLY SECURED BEFOREOPERATING OR TRAILERING YOUR BOAT. IF THE HELM STATION IS NOT PROPER
2870 OFFSHOREWarranty and Warranty Registration CardsThe Pursuit Limited Warranty Statement is included with your boat. It has been written to be cl
2870 OFFSHOREOnce the clear connector is completely installed, the side curtains can be put on. Slide the sidecurtains into the slide tracks on the
2870 OFFSHOREChapter 12:INTERIOR EQUIPMENT12.1 Marine Head SystemYour boat is equipped with a marine head system. The flush water issupplied by a
2870 OFFSHORE12-2Holding Tank and Macerator Discharge PumpThe holding tank is located in the bilge. When the tank is full it must either be pumped o
2870 OFFSHORE12-312.3 Air Conditioner (Dealer Installed Option)The air conditioning unit is the reverse cycle type and operates on 110 volt AC power
2870 OFFSHORE12-4If you did not receive a manual for your stove, please contact the Pursuit Customer RelationsDepartment.THE STOVE IS DESIGNED AS AN
2870 OFFSHORE12-5CO POISONING PRODUCES FLUE-LIKE SYMPTOMS: WATERY AND ITCHY EYES, HEAD-ACHES, AND FATIGUE. YOU CAN'T SEE IT AND YOU CAN'T
2870 OFFSHORETHIS PAGE WAS LEFT BLANKINTENTIONALLY
2870 OFFSHOREChapter 13:ROUTINE MAINTENANCE13.1 Exterior Hull and DeckHull Cleaning-Below The Water LineWhen the boat is removed from the water, cle
2870 OFFSHOREBoats stored in saltwater will typically need to have the anodes replaced at least every 6 months toone year. Anodes requiring replacem
2870 OFFSHOREAnodized Aluminum SurfacesAnodized aluminum should be washed periodically with soap and water to keep it clean. If the boatis used in s
Comments to this Manuals