PURSUIT 3070 EXPRESS Owner's Manual Page 167
- Page / 169
- Table of contents
- TROUBLESHOOTING
- BOOKMARKS
Rated. / 5. Based on customer reviews
3070 EXPRESS
Appendix E:
TROUBLESHOOTING
GUIDE
• Steering system is low on fluid. Fill and bleed system.
• Steering system has air in it. Fill and bleed system.
• A component in the steering system is binding. Check
and adjust or repair binding component.
• Engine steering spindle is binding. Grease spindle.
• There could be air in the steering system. Fill & bleed
the system.
• The engine steering tab is corroded or out of adjust-
ment. Replace or adjust steering tab.
• Engine steering spindle is binding. Grease spindle.
• The control cable is out of adjustment & not activating
the neutral safety cut out switch.
• The shift control lever is not in the neutral detent. Try
moving the shift lever slightly.
• There is a loose wire on the neutral safety switch on
the transmission. Inspect wires and repair loose
connections.
• The starter or ignition switch is bad.
• The boat may be need to have marine growth cleaned
from hull and running gear.
• Propeller may be damaged & need repair.
• Weeds or line around the propeller. Clean propeller.
• Boat is overloaded. Reduce load.
• Check for excessive water in the bilge. Pump out
bilge & find & correct the problem.
• The throttle adjustments has changed and the engine
is not getting full throttle. Adjust the throttle cable.
• Propeller may be damaged & need repair.
• The propeller or propeller shaft is bent. Repair or
replace damaged components.
• The running gear is fouled by marine growth or rope.
Clean running gear.
• The engine is not trimmed Properly. Trim engine.
CONTROL SYSTEMS
Hydraulic Steering is slow to respond & erratic.
The boat wanders and will not hold a course at cruise
speeds.
The engine will not start with the shift control lever
in
neutral.
PERFORMANCE PROBLEMS
Boat is sluggish and has lost speed & RPM.
The boat vibrates at cruising speeds.
PROBLEM CAUSE AND SOLUTION
E-1
- OWNER’S MANUAL 1
- SAFETY INFORMATION 3
- BOAT INFORMATION 5
- (For Export Only) 7
- IMPORTANT INFORMATION 9
- 3070 EXPRESS 10
- OWNER'S/OPERATOR'S 11
- RESPONSIBILITIES 11
- TABLE OF CONTENTS 13
- Chapter 5: Freshwater System 14
- Chapter 6: Raw Water System 14
- Chapter 7: Drainage Systems 14
- Chapter 8: Ventilation System 15
- Chapter 9: Exterior Equipment 15
- Chapter 11: Safety Equipment 16
- Chapter 12: Operation 16
- Chapter 15: Schematics 17
- Chapter 1: 19
- PROPULSION SYSTEM 19
- 1.2 Drive System Corrosion 20
- 1.3 Engine Lubrication 20
- 1.4 Engine Cooling System 21
- 1.5 Propellers 21
- 1.6 Engine Instrumentation 22
- Chapter 2: 25
- HELM CONTROL SYSTEMS 25
- 2.3 Neutral Safety Switch 26
- 2.5 Engine Stop Switch 27
- 2.6 Steering System 28
- 2.7 Trim Tabs 28
- Chapter 3: 31
- FUEL SYSTEM 31
- 3.2 Outboard Fuel System 33
- 3.4 Fueling Instructions 35
- 3.5 Fuel System Maintenance 37
- Chapter 4: 39
- ELECTRICAL SYSTEM 39
- 4.3 AC System 46
- Chapter 5: 55
- FRESHWATER SYSTEM 55
- 5.3 Water Heater 56
- 5.5 Shower Operation 57
- Chapter 6: 59
- RAW WATER SYSTEM 59
- 6.3 Livewell 61
- 6.4 Air Conditioning Pump 62
- Chapter 7: 63
- DRAINAGE SYSTEMS 63
- 7.4 Bilge Drainage 64
- 7.6 Water System Drains 65
- 7.7 Cabin Drains 66
- 7.8 Rope Locker Drains 66
- Chapter 8: 69
- VENTILATION SYSTEM 69
- 8.5 Maintenance 71
- Chapter 9: 73
- EXTERIOR EQUIPMENT 73
- 9.2 Hull 75
- 9.3 Cockpit 76
- Chapter 10: 83
- 10.2 Refrigerator (AC / DC) 85
- 10.3 Air Conditioner 85
- 10.4 Galley and Sink 86
- 10.5 Carbon Monoxide Detector 87
- 10.6 Dinette and Table 88
- 10.7 V-Berth 88
- 10.8 T.V 89
- Chapter 11: 91
- SAFETY EQUIPMENT 91
- 11.3 Neutral Safety Switch 92
- 11.4 Engine Stop Switch 92
- 11.6 Carbon Monoxide Detector 95
- 11.7 First Aid 97
- Chapter 12: 101
- OPERATION 101
- 12.3 Pre-Cruise Check 103
- 12.4 Operating Your Boat 104
- 3070 EXPRESS 105
- 12.8 Collision 110
- 12.10 Flooding or Capsizing 112
- 12.11 Fishing 112
- 12.12 Man Overboard 112
- 12.13 Trash Disposal 113
- 12.14 Transporting Your Boat 113
- Chapter 13: 115
- ROUTINE MAINTENANCE 115
- 13.3 Cabin Interior 120
- 13.4 Bilge 121
- 13.5 Generator (Optional) 121
- 13.6 Drainage System 121
- Chapter 14: 123
- SEASONAL MAINTENANCE 123
- 14.2 Winterizing 126
- 14.3 Recommissioning 130
- Chapter 15: 133
- SCHEMATICS 133
- APPENDIX A: 149
- GLOSSARY OF TERMS 149
- Appendix B: 157
- MAINTENANCE SCHEDULE AND LOG 157
- MAINTENANCE LOG 158
- BOATING ACCIDENT REPORT 163
- Appendix D: 165
- FLOAT PLAN 165
- Appendix E: 167
- TROUBLESHOOTING 167
Related products and manuals for Toys & accessories PURSUIT 3070 EXPRESS
Toys & accessories PURSUIT OS 315 Owner's Manual
(112 pages)
(112 pages)
Toys & accessories PURSUIT OS 285 Owner's Manual
(134 pages)
(134 pages)
Toys & accessories PURSUIT OS 315 Owner's Manual
(128 pages)
(128 pages)
Toys & accessories PURSUIT LS 235 Owner's Manual
(116 pages)
(116 pages)
Toys & accessories PURSUIT DC 325 Owner's Manual
(146 pages)
(146 pages)
Toys & accessories PURSUIT S280 Owner's Manual
(145 pages)
(145 pages)
Toys & accessories PURSUIT C 230 Owner's Manual
(114 pages)
(114 pages)
Toys & accessories PURSUIT OS 385 Owner's Manual
(144 pages)
(144 pages)
Toys & accessories PURSUIT C 340 Owner's Manual
(122 pages)
(122 pages)
Toys & accessories PURSUIT OS 255 Owner's Manual
(118 pages)
(118 pages)
Toys & accessories PURSUIT OS 335 Owner's Manual
(136 pages)
(136 pages)
Toys & accessories PURSUIT SF 345 Owner's Manual
(130 pages)
(130 pages)
Toys & accessories PURSUIT OS 375 Owner's Manual
(146 pages)
(146 pages)
© 2020, manymanuals.com. All rights reserved. | 0.243 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comments to this Manuals